Parking Garage Systems
Deck, structure and coating handled as one system, in garages that have to stay open while the work goes on, across NYC and the tri-state area.
A parking deck is the hardest working concrete a building owns.
It carries traffic, road salt, standing water and thermal movement at once, and chlorides work down through the slab to attack the reinforcement inside it. Left alone that stops being a maintenance item and becomes a structural one.
We take the whole system, because a garage that is repaired but not coated is a garage that will be repaired again: the concrete, the joints, the membrane and the wearing surface are one job, sequenced bay by bay so the structure keeps operating throughout. Large parking garage renovation is programmed the same way, level by level, so a structure of any size keeps earning while it is put right.
Every item is performed by our own crews.
Repairs to concrete that carries load, engineered before it is opened up: what is wrong, what has to be shored while it is out, and what the repaired section has to carry once it is back in service.
Full deck programs taken level by level: sounding the slab to map delamination, removing unsound concrete, treating or replacing reinforcement, rebuilding the section and re establishing the wearing surface above it. Phased so the structure stays open and in revenue while it is repaired.
Failed joints cut out, the blockout rebuilt to sound concrete and a new joint system installed to suit the movement and the traffic it carries. A garage moves with temperature, and a joint that cannot take that movement becomes the leak.
Vehicular traffic coatings applied over prepared decks: a base coat that bridges hairline cracking, a wear coat, and aggregate broadcast where the surface needs grip. The coating carries tire scrub and turning loads as well as water.
Elastomeric urethane deck systems for surfaces that must stay flexible and waterproof under traffic. Urethane keeps its elongation cold, which is what lets it stay bonded across a crack that opens and closes through the year.
Membrane systems that make the deck itself the waterproofing layer, detailed through drains, columns, curbs and joints. Water stopped at the driving surface never reaches the reinforcement or the cars parked below.
Slab areas removed to sound material and rebuilt, full depth where the deterioration goes through and partial depth where it does not, with the reinforcement exposed, cleaned and continuous before anything is placed.
Spalled concrete cut back to a square edge, corroded steel cleaned or replaced, and the section rebuilt with a repair mortar matched to the exposure. Feathered edges fail, so repairs are cut to a shoulder the material can key into.
Structural cracks injected with epoxy to restore monolithic behavior, or with polyurethane resin where the crack is live and the requirement is to stop water rather than to bond.
See also: Flooring Systems · Waterproofing Systems
The same elevation before and after. Deteriorated painted masonry, a failed parapet and fascia, and a broken apron; then rebuilt, with a new stone base, the parapet made good and the paving resurfaced.
Photography from the company's own projects.
Short clips from the company's own jobs. Nothing downloads until you press play.
Yes. This category is carried out by our own crews rather than subcontracted, which is why we can commit to a schedule and to emergency response.
All five boroughs, Westchester, Long Island and out across the tri-state area, NY, NJ and CT.
Yes. Permits, expediting and violation removal run alongside the field work on the same job, so the correction and the paperwork close out together.
Renovation work rarely stops at one system. These are the ones that most often run alongside it.
Send the report, the violation or a photograph and you will get a straight answer.
